P822 and M6720 - controller not detecting existing array / logical drive

[dww0311]

Environment:

DL360 Gen8, with P822 installed. One EMC SAE shelf, one HP M6720 shelf, both populated with 24 drives. Each had one array / logical drive defined on it. After trying to configure both for MPIO, upon reboot neither array /. LD was detected. 

I recreated the array / LD set on the EMC as that one was esentially empty and the data which was there was easy to replace. The larger M6720 array / LD, however, will take months to replace one unit at a time from source (there is no backup). No changes have been made to the drives / array (ie no new array creation, etc. ) The controller simply will not detect the existing logical drive on the disks. 

I also note that the dignostic report seems confused about which drives are in which enclosure. It's a mess. Any ideas? Diagnostic report attached below

[dww0311]

ACU Version 9.40.12.0
Diagnostic Module Version 6.2.25.0
INFOMGR Version 6.1.29.0
Time Generated Friday January 23, 2026 3:59:44PM

Device Summary:
Smart Array P822 in slot 2

Consolidated Error Report:
Controller: Smart Array P822 in slot 2
Device: Logical Drive 1
Message: Logical drive state: Background parity initialization is currently in progress on this logical drive. When background parity initialization completes, the performance of the logical drive will improve.

Report for Smart Array P822 in slot 2
-------------------------------------

Smart Array P822 in slot 2 : Device Error Report

Device Severity Error
--------------- -------- ----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
Logical Drive 1 Info Logical drive state: Background parity initialization is currently in progress on this logical drive. When background parity initialization completes, the performance of the logical drive will improve.

Smart Array P822 in slot 2 : Identify Controller

Configured Logical Drives 1 (0x01)
Configuration Signature 0xac177c8d
RAM Firmware Revision 8.32
ROM Firmware Revision 8.32
Hardware Revision 0x01
Boot Block Revision 1.90
Drive Present Map 0x00000000
External Drive Map 0x00000000
Board ID 0x3353103c
Swapped Cable Flags 0x02
Position Swapped Cable Flag Status
-------- ------------------------------------- -------------
1 Drives appear to have been rearranged Informational

Non Disk Map 0x00000000
Bad Host RAM Addr 0x00
CPU Revision 0x28
PDPI Revision 0x00
EPIC Revision 0x00
WCXC Revision 0x00
Marketing Revision B
Controller Flags 0x8c
Position Controller Flag Status
-------- ---------------------------------------------------------------------------------------------------------------------------------------------------- -------------
2 Firmware has been upgraded to support capacity expansion operations that require more than 65535 sectors (32MB) to be relocated per expand iteration Informational
3 Firmware supports 15 drives per SCSI bus Informational
7 Firmware supports the new big drive assignment maps (128 bits) as well as the big physical drive numbering (0x80+) Informational

Host Flags 0x02
Expand Disable Code 0x01
Position Expand Disable Code Status
-------- ------------------- -------------
0 Expand Not Needed Informational

Protocol Chip Count 0x01
Maximum Blocks 65535 (0x0000ffff)
Controller Clock 0x000130b4
Drives Per Bus 0 (0x00)
Big Drive Present Map 0x00 0xff 0xff 0xff 0xff 0xff 0xff 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
Position Device Status
-------- ------------------------------------------- -------------
8 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
9 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
10 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
11 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
12 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
13 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
14 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
15 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
16 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
17 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
18 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
19 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
20 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
21 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
22 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
23 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
24 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
25 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
26 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
27 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
28 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
29 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
30 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
31 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
32 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
33 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
34 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
35 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
36 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
37 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
38 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
39 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
40 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
41 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
42 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
43 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
44 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
45 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
46 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
47 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
48 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
49 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
50 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
51 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
52 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
53 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
54 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
55 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational

Big External Drive Map 0x00 0xff 0xff 0xff 0xff 0xff 0xff 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
Position Device Status
-------- ------------------------------------------- -------------
8 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
9 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
10 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
11 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
12 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
13 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
14 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
15 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
16 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
17 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
18 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
19 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
20 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
21 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
22 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
23 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
24 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
25 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
26 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
27 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
28 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
29 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
30 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
31 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
32 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
33 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
34 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
35 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
36 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
37 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
38 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
39 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
40 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
41 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
42 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
43 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
44 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
45 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
46 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
47 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
48 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
49 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
50 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
51 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
52 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
53 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
54 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
55 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational

Big Non Disk Map All Zeroes (16 x [0x00])
Task Flags 0x04c0
Busses For ICL 0 (0x00)
Supported Controller Modes 0x00
Current Controller Mode Not Redundant (0x00)
Controller Status 0x00
Position Controller Status Status
-------- ----------------- -------------
0 Location External Informational

Redundant Failure Reason 0x00
Unsupported NILE Busses 0x00
Host I2C Autorev 0x03
CPLD Revision 0x0c
Fibre Chip Count 0 (0x00)
Daughterboard Type 0x00
More Swapped Cable Flags 0x00
License Key Status 0x00
Position License Key Status Status
-------- ---------------------------- -------------
3 License Keys Supported False Informational

Access Module Status 0x07
ADG Support 0xc1
Features Supported 0xff 0xfc 0x00 0x00 0xff 0x03 0x81 0x01 0x00 0x00 0x00
ROM Inactive Revision 8.32
Active ROM Status 0x00
PPC to PCI Bridge Status 0x00
Redundant Server Info 0x00000000
Percent Write Cache 90% (0x5a)
Cache Size In MB 2.0 GB (0x0800)
Cache Battery Count 1 (0x01)
Total Controller Memory Size 0x0800
More Controller Flags 0xf8
Position Controller Flag Status
-------- ----------------------------------------------------------------------------------- -------------
3 Firmware supports deferred code load drive firmware updates Informational
4 Firmware supports basic splitting and resyncing of mirrored volumes Informational
5 Controller implements SAS changes documented in the firmware spec Informational
6 Controller supports variable-length extended physical drive map and drive numbering Informational
7 Firmware supports greater than 2TB logical volumes Informational

XBoard Host I2C Autorev 0x00
Battery PIC Revision 0x32
DDFF Version 0202
Maximum Logical Devices Supported 64 (0x0040)
Extended Logical Unit Count 1 (0x0001)
Maximum Physical Devices Supported 384 (0x0180)
Maximum Physical Drives Per Logical Unit 128 (0x0080)
Enclosure Count 2 (0x02)
Expander Count 2 (0x02)
Offset To Extended Drive Present Map 290 (0x0122)
Offset To Extended External Drive Map 338 (0x0152)
Offset To Extended Non Disk Map 386 (0x0182)
Internal Port Status 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
External Port Status 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
Yet More Controller Flags 0xfa57a216
Position Controller Flag Status
-------- -------------------------------------------- -------------
1 This is a SAS controller that supports OBDR Informational
2 Reorder logical drive operation is supported Informational
4 Multiple Parity Groups Supported Informational
9 Ncq Supported Informational
13 PHY-to-PHY map is supported Informational
15 Sat Pass Through Read Supported Informational
16 Sat Pass Through Write Supported Informational
17 Multi Domain Supported Informational
18 Sas Zoning Supported Informational
20 Fixed Fields Length Supported Informational
22 Sense Expansion Ability Supported Informational
25 Hba Mode Supported Informational
27 Cache Config Flags Supported Informational
28 Boot Volume Supported Informational
29 Periodic Sampling Supported Informational
30 Step Internal Option Rom Supported Informational
31 Flash Backed Write Cache Supported Informational

Last Lockup 0x00
PCI Slot 2 (0x02)
Firmware Build Number 0x0000
Maximum Safe Full Stripe Size MB 12 MB (0x0000000c)
Total Structure Length 482 (0x000001e2)
Vendor ID HP
Product ID P822
Extended Last Lockup 0x00000000
Maximum RAID01 Stripe Size 0xffff
Maximum RAID45 Stripe Size 0x0800
Maximum RAID6 Stripe Size 0x0800
Yet More Swapped Cable Flags 0x0000
Maximum Device Paths 0x04
Offset To Zoned In Drive Map 0 (0x0000)
Fixed Structure Length 290 (0x00000122)
Firmware Compile Time Stamp Sep 12 2017 17:18:30
Even More Controller Flags 0x20c7d630
Position Controller Flag Status
-------- ---------------------------------------------- -------------
16 Rapid Parity Initialization Supported Informational
17 Io Bypass Function Supported Informational
18 Roaming Spares Supported Informational
23 Enhanced Rapid Parity Initialization Supported Informational

Host Initialization Code 0x0220
Orca Image Size 0x0000
Option ROM Version empty
Option ROM Build 0x0000
Encryption Status 0x0000
Extra Controller Flags 0x00040000
Extended Drive Present Map 0x00 0xff 0xff 0xff 0xff 0xff 0xff 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
Position Device Status
-------- ------------------------------------------- -------------
8 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
9 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
10 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
11 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
12 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
13 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
14 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
15 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
16 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
17 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
18 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
19 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
20 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
21 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
22 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
23 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
24 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
25 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
26 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
27 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
28 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
29 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
30 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
31 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
32 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
33 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
34 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
35 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
36 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
37 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
38 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
39 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
40 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
41 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
42 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
43 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
44 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
45 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
46 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
47 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
48 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
49 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
50 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
51 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
52 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
53 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
54 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
55 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational

Extended External Drive Map 0x00 0xff 0xff 0xff 0xff 0xff 0xff 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
Position Device Status
-------- ------------------------------------------- -------------
8 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
9 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
10 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
11 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
12 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
13 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
14 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
15 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
16 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
17 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
18 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
19 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
20 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
21 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
22 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
23 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
24 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
25 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
26 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
27 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
28 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
29 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
30 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
31 Physical Drive (1200.2 GB SAS) 3E:1:Unknown Informational
32 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
33 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
34 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
35 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
36 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
37 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
38 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
39 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
40 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
41 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
42 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
43 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
44 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
45 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
46 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
47 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
48 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
49 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
50 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
51 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
52 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
53 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
54 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational
55 Physical Drive (6001.1 GB SAS) 4E:1:Unknown Informational

Extended Non Disk Map 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00
0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x00 0x1f
Position Device Status
-------- ------------------------------------- -------------
376 Enclosure SEP (XYRATEX HB-2435-E6EBD) Informational
377 Informational
378 Enclosure Expander Informational
379 Informational
380 SEP (PMCSIERA SRCv24x6G) Informational

[Azr_geek]

Hello @dww0311,

When you enabled or changed things related to MPIO / multipath, the controller probably:

• Re-enumerated the disks
• Changed enclosure IDs or path order
• Or switched from “single path” view to “dual path” view

Because of that, the P822 now thinks the disks belong to a different enclosure or are new, even though the data is still physically on them.

That explains why:
• The logical drive is not detected
• The diagnostic report is confused about which drives are in which shelf

This is very common with external SAS shelves + multipath changes.

Safe things to try first

Check in SSA (Smart Storage Administrator)

Look for:
• “Unassigned Drives”
• “Foreign Configuration”
• “Logical drive is offline”

Look for a “Recover Logical Drive” option

Sometimes shown as “Re-enable”, “Import configuration”, or “Reactivate”

If offered, this is usually safe

Verify cabling

Ensure both SAS cables from the M6720 are connected to the same controller

No cable swaps compared to before

Temporarily disconnect the EMC shelf

Boot with only the M6720 connected

This reduces enclosure confusion

If firmware is old, the controller may not re-recognize the array.

Check and update in this oder:

• P822 controller firmware
• Server system ROM
• M6720 expander firmware

Firmware updates are usually safe, but do not update if the tool says it will reset or clear array configuration.

If the issue persists:

At that point, the best next step is:

• HP SSA CLI (ssacli)
• Look for a foreign or offline configuration
• Manually force a re-scan or import

If even that fails, HP support or a data recovery service that understands Smart Array metadata may still recover it — because the array was never overwritten. Focus on re-importing or re-detecting the logical drive

Regards,
Azr_geek

[support_s]

Hello,

Let us know if you were able to resolve the issue.

If you are satisfied with the answers then kindly click the "Accept As Solution" button for the most helpful response so that it is beneficial to all community members.

Please click on "Thumbs Up/Kudo" icon to give a "Kudo".